Product ID:G8005 FAST DRY POYURETHANE PRIMER SURFACER WHITE BASE
MSDS Date:09/28/1990
FSC:8010
NIIN:00F051755
MSDS Number: CCFRF

US PAINT CORPORATION (FORMERLY GROU GROUP INC)

831 S 21ST ST
ST LOUIS, MO 63103-3043
US

Emergency Phone: 314-621-0525/202-483-7616

Info Phone: 314-621-0525/202-483-7616

Cage: EO831

US PAINT CORPORATION

ST LOUIS, MO 63103-3092 US

Telephone: 314-621-0525

Cage: EO831

PROPYLENEGLYCOL MONOMETHYL ETHER ACETATE,

CAS: 108-65-6

RTECS: AI8925000

Fraction By Weight: 4%

CELLOSOLVE ACETATE (ETHYLENE GLYCOL ETHYL ETHER ACETATE),

CAS: 111-15-9

RTECS: KK8225000

Fraction By Weight: 29%

OSHA PEL 100 PPM

ACGIH TLV: 5 PPM SKIN

ACETIC ACID, ETHYL ESTER, ETHYL ACETATE * 96-3 *

CAS: 141-78-6

RTECS: AH5425000

Fraction By Weight: 2.16%

OSHA PEL 1400 MG/CUM

ACGIH TLV: 1400 MG/CUM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

TOLUENE (IARC CARC- GROUP 3) *96-3*

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 1%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES: CAN CAUSE SEVERE IRRITATION.
SKIN: CAN CAUSE MODERATE IRRITATION & DERMATITIS. INHALATION: CAN
CAUSE NASAL & RESPIRATORY IRRITATION & ASPHYXIATION. INGESTION:
HARMFUL, CAN CAUSE BURNING SENSATIO N.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, TEARING, REDDENING, BLURRED,
SWELLING, SCALING, BLISTERING, DIZZINESS, WEAKNESS, FATIGUE,
NAUSEA, HEADACHE, UNCONSCIOUSNESS, SENSATION, VOMITING, DIARRHEA.

First Aid:SKIN: WASH THOROUGHLY W/SOAP & WATER. EYES: FLUSH W/LARGE
AMOUNTS OF WATER FOR 15 MINS. INGESTION: DON'T INDUCE VOMITING.
INHALATION: REMOVE TO FRESH AIR. IF BREATHING HAS STOPPED, GIVE
CPR. IF BREATH ING IS DIFFICULT, GIVE OXYGEN. OBTAIN MEDICAL
ATTENTION IN ALL CASES.

Flash Point Method:TCC
Flash Point:24F
Lower Limits:1.2
Upper Limits:7
Extinguishing Media:DRY CHEMICAL, FOAM.
Fire Fighting Procedures:KEEP AWAY FROM ALL IGNITION SOURCES. USE FULL
PROTECTIVE CLOTHING INCLUDING SCBA.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. VAPORS MAY IGNITE EXPLOSIVELY. VAPORS MAY
SPREAD LONG DISTANCES & BEYOND CLOSED DOORS. (SUPP)

Spill Release Procedures:SMALL: ABSORB ON INERT MATERIAL SUCH AS PAPER,
VERMICULITE, FLOOR ABSORBENT & TRANSFER TO HOOD. LARGE ELIMINATE
ALL IGNIOTN SOURCES. CONTAIN AREA TO PREVENT SPREADING. PUMP LIQUID
TO SALVAGE TANK. ABS ORB REMAINING LIQUID W/INERT MATERIAL.

Handling and Storage Precautions:KEEP CLOSURE TIGHT & UPRIGHT TO
PREVENT LEAKAGE. KEEP CLOSED WHEN NOT IN USE. DON'T STORE ABOVE
120F. CONTAINERS RETAIN PRODUCT RESIDUE.

Respiratory Protection:WEAR APPROPRIATE, PROPERLY FITTED-NIOSH/MSHA
APPROVED RESPIRATOR IF LEVELS ARE ABOVE APPLICABLE LIMITS.
Ventilation:ADEQUATE
Protective Gloves:IMPERMEABLE
Eye Protection:SOLVENT RESISTANT SAFETY EYEWEAR
Supplemental Safety and Health

Boiling Pt:B.P. Text:169-329F
Vapor Density:>1
Spec Gravity:1.42
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:71

Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS.
Stability Condition to Avoid:EXCESS HEAT.
Hazardous Decomposition Products:CO, CO2, OXIDES OF NITROGEN.

Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. ALLOW VOLATILE PORTION TO EVAPORATE IN HOOD BEING SURE
TO ALLOW SUFFICIENT TIME FOR VAPORS TO COMPLETELY CLEAR HOOD DUCT
WORK. DON'T INCINERATE.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.